Friday, December 06, 2019
Hawai'i Free Press

Current Articles | Archives

Friday, September 13, 2013
$340K in Fines: Hawaii Wins Back OSHA Job After Unicold Raid
By News Release @ 11:45 PM :: 6217 Views :: Hawaii State Government, Labor, Small Business

STATE CITES WAREHOUSE TENANTS WITH 59 SAFETY AND HEALTH VIOLATIONS

$340,595 in Total Proposed Penalties Issued by HIOSH and US Department of Labor

News Release from DLIR September 13, 2013

HONOLULU—The Hawaii State Department of Labor and Industrial Relations’ (DLIR) Hawaii Occupational Safety and Health Division (HIOSH) has issued 59 serious citations with proposed fines of up to $89,265 to 10 tenants of Unicold Corporation’s refrigerated food warehouse in Honolulu. Unicold and the tenants face $340,595 in total proposed fines following joint inspections conducted by the U.S. Department of Labor’s Occupational Safety and Health Administration and HIOSH.

The serious violations inspectors found include providing only one exit door, some of which were not side hinged, failure to select appropriate exit routes, train employees in the routes and hold periodic evacuation drills; neglecting to label routes that were not exits, obstructions to exit doors, and failure to train employees in the hazards of ammonia. A serious violation occurs when there is substantial probability that death or serious physical harm could result from a hazard about which the employer knew or should have known.

“The workers were exposed to grave hazards due to the employers’ decision to obstruct emergency routes to enlarge the available storage space,” said DLIR Director Dwight Takamine.

“We are very fortunate that a tragic event did not occur, especially as the danger involved the potential of leaking ammonia, which could have exposed workers to asphyxiation, chemical and thermal burns, and other hazards. This could have been worse than the tragedy that occurred in the Waikele Bunker explosion in April 2011.”

“We hope the employers will act swiftly to correct the serious issues identified through this collaborative effort between OSHA and HIOSH,” said Galen Lemke, Director of the Honolulu Federal OSHA Office. “This is a good example of how federal and state actions can help achieve our common goal of providing safe and healthy workplaces for Hawaii’s workforce.”

Other serious violations cited included hazards relating to improper use of forklifts as personnel lifts, forklifts in disrepair, expired training credentials for forklift operators, unguarded machinery, damaged storage systems, and inadequate electrical equipment.

The companies cited for one or more of the above violations include Ramar International Corporation, P&E Foods, Norpac Fisheries, Love’s Bakery, Lappert’s Inc., Kahuna Distribution LLC, Eskimo Candy Oahu, Eight Point Distributors, Choyce Products, and C&S Wholesale Grocers.

To ask questions, obtain compliance assistance, file a complaint, or report workplace hospitalizations, fatalities or situations posing imminent danger to workers, the public should call OSHA’s toll-free hotline at 800-321-OSHA (6742), the agency’s Honolulu office at 808-541-2680 or the HIOSH office at 808-586-9092.

Under the Occupational Safety and Health Act of 1970, employers are responsible for providing safe and healthful workplaces for their employees. HIOSH’s role is to ensure these conditions for Hawaii’s working men and women by setting and enforcing standards, and providing training, education and assistance. For more information, visit http://labor.hawaii.gov/hiosh/ or http://www.osha.gov.

#####

Star-Adv Sept 13, 2013: Feds give back factory workplace safety oversight to state

CB Sept 13, 2013: Feds Let Hawaii Resume Control of Regulating Manufacturing Industries

August 13, 2013: OSHA hits Hawaii refrigerated food warehouse: $253K Fine, 63 Violations

PBN:  “For the first year they wanted us to do 300 inspections; We’re on course do somewhere in the neighborhood of 500.”

Renewed commitment to workplace safety, health

News Release from DLIR

The state Department of Labor & Industrial Relations (DLIR) and the Occupational Safety and Health Administration (OSHA) have announced that improvements in Hawaii’s workplace safety and health during the last year will result in the Hawaii Occupational Safety and Health Division (HIOSH) reassuming responsibility for regulating Hawaii’s manufacturing industries.

OSHA and HIOSH have shared regulatory responsibility for Hawaii per an agreement that clearly divides enforcement responsibilities. The Operational Status Agreement (OSA) went into effect last September and was designed to jointly rebuild and strengthen the safety and health regulatory environment in Hawaii.

The OSA, a procedural agreement, provides a roadmap for how the OSHA and DLIR’s HIOSH will work together to meet safety and health goals and assure safe and healthful working conditions for Hawaii’s workers.

“By continuing to work together closely with OSHA, and in partnership with employers, we are on track in rebuilding the HIOSH program. A strong HIOSH not only lowers injury and illness rates, but also improves the overall work environment and accountability,” Gov. Neil Abercrombie said. “This Administration is committed to restoring the state’s ability to assure workplace safety and health.”

The agreement suspended HIOSH’s enforcement authority in specific industries where OSHA assumed responsibility for enforcement until the state is able to be “at least as effective” as OSHA. The partnership allows OSHA to commit the resources and staff necessary to provide the training and support, which will enable HIOSH to reassume sole enforcement authority in the state.

HIOSH will progressively resume authority over industries as it rebuilds capacity during the three-year period outlined in the agreement. The return of the manufacturing sector to HIOSH jurisdiction is the first sector that was scheduled in the OSA to return to HIOSH.

“One of my first and ongoing priorities in the department has been the restoration of HIOSH,” DLIR Director Dwight Takamine said. “Much of that effort has involved staff recruitment for the division and continuously seeking advice and help from our federal partners. The return of the Manufacturing sector to our jurisdiction recognizes that we are hitting those milestones necessary to re-establish meaningful safety and health regulation, although the work is not finished.”

The progress being made to improve worker safety and health in Hawaii through this cooperative effort is encouraging to see,” said Dr. David Michaels, Assistant Secretary of Labor for OSHA. “HIOSH, and all of our State partners are an integral part of the national OSHA effort to level the playing field by enforcing rules that everyone must follow to strengthen our economy, prevent serious injuries and illnesses, and save lives.

“Enforcement responsibilities are clearly divided to ensure that no one in the employer community needs to be confused about which agency is regulating their industry during the agreement,” said HIOSH Advisory Board Chair Chuck Beneke.

“We are continuing to conduct outreach to the employer community to minimize confusion as to which agency has jurisdiction as well as the safety and health standards that are applicable,” Beneke said.

HIOSHViolations

BACKGROUND

In 2009, 32 of 51 HIOSH positions were eliminated during the 2009 Reduction-in-Force process. Sixteen of the 32 were benchmarked positions that contributed to meeting the necessary OSHA staffing requirements — OSHA requires HIOSH to have 22 specific positions in compliance and consultation.

In FY 2009, HIOSH completed only 426 inspections (51 percent) of its goal of 835 inspections. Due to the Reduction-in-Force in 2009, only 12 of the 22 benchmarked positions were authorized in the Executive Budget and only 10 of the 12 positions were filled.

OSHA released a Federal Annual Monitoring and Evaluation Report (FAME) covering federal fiscal year 2009 in September 2010 that raised numerous concerns about Hawaii’s program including the following:

* “Additional layoffs…occurred in the first quarter of FY10, and the staff was further reduced to nine compliance staff (50 percent below the benchmark) and one consultant (75 percent below the benchmark).”

* “In 24 of the 43 case files reviewed [in 2009], HIOSH did not appropriately classify the violations and/or cite all the hazards. Seven other-than-serious (OTS) should have been classified as serious (S). There were 19 case files where the narrative or a photo provided sufficient information to document a hazard which was not cited.”

* “The person designated as the HIOSH Administrator in the 23g Grant was not assigned to the duties of the Administrator as described by the HIOSH FOM [Field Operations Manual].

The 2010 Legislature restored 12 of the positions abolished during the Reduction-in-Force, though the department did not move to fill the positions until the start of the Abercrombie Administration.

Beginning in December 2010, the Abercrombie Administration initiated recruitment for the positions and the conversion of nine of the restored positions to meet the OSHA benchmark staffing requirements.

The HIOSH Administrator was also assigned back to the management of the division.

The Occupational Safety and Health Act, signed by President Richard Nixon on Dec. 29, 1970, established OSHA under the U.S. Department of Labor. OSHA’s mission is to “assure safe and healthful working conditions for working men and women by setting and enforcing standards and by providing training, outreach, education and assistance.”

The Act also encourages states to develop and operate their own job safety and health programs. OSHA approves and monitors state plans and provides up to 50 percent of an approved plan’s operating costs. OSHA relinquishes enforcement authority in states that obtain approval for their own plans and Hawaii was the first state granted final approval on April 30, 1984.

States must set job safety and health standards that are “at least as effective as” federal standards and may promulgate stricter standards or ones covering hazards not addressed by federal standards.

A state must conduct inspections to enforce its standards, cover both the private and public sectors, and operate occupational safety and health training and education programs.

In addition, most states including Hawaii, provide free on-site consultation to help employers identify and correct workplace hazards.

For details about the OSA and FAQs, visit: labor.hawaii.gov/hiosh/hiosh-n…


 

Links

TEXT "follow HawaiiFreePress" to 40404

Register to Vote

2aHawaii

808 Silent Majority

808 State Update AM940

ABCDEFG Blog

ACA Signups Hawaii

ACCE

ALEC

Alliance Defending Freedom

Aloha Life Advocates

Aloha Pregnancy Care Center

American Council of Trustees and Alumni

American Mothers of Hawaii

AMVETS-Hawaii

AntiPlanner

Antonio Gramsci Reading List

A Place for Women in Waipio

Audit The Rail

Ballotpedia Hawaii

Better Hawaii 

Blaisdell Memorial Project

Broken Trust 

Build More Hawaiian Homes Working Group

CAFR Hawaii

Castaway Conservative

Children's Alliance Hawaii

Children's Rights Institute

ChinaTownWatch.com

Christian Homeschoolers of Hawaii

Citizens for Recall

Cliff Slater's Second Opinion

Coffee Break

CSIS Pacific Forum

DAR Hawaii

DeedySupport.com

DVids Hawaii

E Hana Kakou Kelii Akina

E Māua Ola i Moku o Keawe

Farmers For Choice Hawaii

FIRE

Fix Oahu!

Follow the Money Hawaii

Frank in Hawaii

Front Page Magazine

Frontline: The Fixers

Genetic Literacy Project

Get Off Your Butts!

God, Freedom, America

Grassroot Institute

Habele.org

Hawaii Aganst Assisted Suicide

Hawaii Aquarium Fish Report

Hawaii Aviation Preservation Society

Hawaii Catholic TV

Hawaii Christian Coalition

Hawaii Cigar Association

Hawaii Coalition Against Legalized Gambling

Hawaii ConCon Info

Hawaii Credit Union Watch

Hawaii Crime Victims' Rights

Hawaii Crop Improvement Association

Hawaii Debt Clock

Hawaii Defending Marriage

Hawaii Defense Foundation

Hawaii Families for Educational Choice

Hawaii Family Advocates

Hawaii Family Forum

Hawaii Farmers and Ranchers United

Hawaii Farmer's Daughter

Hawaii Federalist Society

Hawaii Federation of Republican Women

Hawaii Firearm Community

Hawaii Fishermen's Alliance

Hawaii Future Project

Hawaii Gathering of Eagles

Hawaii History Blog

Hawaii Homeschool Association

Hawaii Jihadi Trial

Hawaii March for Life

Hawaii Meth Project

Hawaii's Partnership for Appropriate & Compassionate Care

Hawaii Public Charter School Network

Hawaii Rifle Association

Hawaii Right to Life -- Big Island

Hawaii Right to Life -- Oahu

Hawaii Shield Law Coalition

Hawaii Shippers Council

Hawaii Smokers Alliance

Hawaii State Data Lab

Hawaii Together

Heritage Foundation

HI Coalition Against Legalized Gambling

HIEC.Coop 

HiFiCo

Hiram Fong Papers

Homeschool Legal Defense Hawaii

Honolulu Homeless Crisis

Honolulu Navy League

Honolulu Traffic

Horns of Jericho Blog

House Minority Blog

House Republican Caucus YouTube

HPACC

Hump Day Report

I Vote Hawaii

If Hawaii News

Imua TMT

Inouye-Kwock, NYT 1992

Inside the Nature Conservancy

Inverse Condemnation

Investigative Project on Terrorism

Iowa Meets Maui

Jackson v Abercrombie

Jihad Watch

Judgepedia Hawaii

July 4 in Hawaii

Kahle v New Hope

Kakaako Cares

Kau TEA Party

Kauai Co GOP

Keep Hawaii's Heroes

KeyWiki

Land and Power in Hawaii

Legislative Committee Analysis Tool

Lessons in Firearm Education

Lingle Years

Malulani Foundation

Managed Care Matters -- Hawaii

Malama Pregnancy Center of Maui

Mauna Kea Recreational Users Group

MentalIllnessPolicy.org

Middle East Forum--The Legal Project

Mililani Conservatives for Change

Military Home Educators' Network Oahu

Missile Defense Advocacy

MIS Veterans Hawaii

Muslim Brotherhood in America

NAMI Hawaii

NARTH

Natatorium.org

National Christian Foundation Hawaii

National Parents Org Hawaii

National Wind Watch

New Zeal

NFIB Hawaii News

No GMO Means No Aloha

Northwest Economic Policy Seminar

Not Dead Yet, Hawaii

Now What I Really Think

NRA-ILA Hawaii

Oahu Alternative Transport

ObamaCare Abortion Hawaii

Obookiah

OHA Lies

Opt Out Today

OurFutureHawaii.com

Pacific Aviation Museum

Patients Rights Council Hawaii

PEACE Hawaii

People vs Machine

Pritchett Cartoons 

Pro-GMO Hawaii

P.U.E.O.

RailRipoff.com

Rental by Owner Awareness Assn

Republican Party -- Hawaii State

Research Institute for Hawaii USA

Rick Hamada Show

RJ Rummel

Robotics Organizing Committee

Salvage The Rail

Save the Plastic Bag

School Choice in Hawaii

SenatorFong.com

SIFE Remington

SIFE W. Oahu 

Sink the Jones Act

Smart About Marijuana--Hawaii

St Marianne Cope

State Budget Solutions Hawaii

State Policy Network

Statehood for Guam

Tax Foundation of Hawaii

The Harriet Tubman Agenda

The Long War Journal

The Real Hanabusa

Time Out Honolulu

Truth About Trade & Technology - Hawaii

UCC Truths

Union Members Know Your Rights

US Tax Foundation Hawaii Info

Valor in the Pacific

VAREP Honolulu

Waagey.org

West Maui Taxpayers Association

What Natalie Thinks

Whole Life Hawaii

Yes2TMT